2022 Kia Carnival Recalls & Problems

“Driving down the road and the digital instrument cluster went out. Newer Kia carnivals have a recall on this but my 2022 is doing it. I can’t see speed, rpm, blinkers, high beam indicator, gas gauge, notifications or anything”

“The power sliding door actuator motor drive cables on my 2022 Kia Carnival snapped on both the passenger and driver sides. The doors are stuck shut, even in manual mode, creating a safety hazard for passengers since the only way to exit in an accident would be through the rear hatch or the front doors. The Kia dealer said they couldn’t open the doors without removing the interior sliding door pane…”

“Driving down the road and the digital instrument cluster went out. Newer Kia carnivals have a recall on this but my 2022 is doing it. I can’t see speed, rpm, blinkers, high beam indicator, gas gauge, notifications or anything”

“Engine light turns on every couple months. The Kia either stops accelerating and goes into “limp mode” or gives code for misfiring cylinders. Took to dealership several times, they did nothing but reset battery so light goes off. Unsafe when driving my family around and has turned into an unreliable vehicle. SO frustrating for a new vehicle to have these issues.”

“SC368 CROSS OVER FUEL PIPE recall incomplete by kia of des moines”

“My front windshield on my 2022 Kia Carnival has shattered in two places from a small hit. I have owned lots of cars and never had a windshield break in two places all the way across. There must be an issue or problem.”

“The contact owns a 2022 Kia Carnival. The contact stated that while the vehicle was parked, she noticed that the windshield was cracked from the passenger's side to the driver's side of the windshield. The vehicle was taken to an auto glass repair shop, where it was determined that the windshield needed to be replaced; however, the replacement windshield was not available. The windshield was repla…”

“The contact owns a 2022 Kia Carnival. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V908000 (Latches/Locks/Linkages, Structure); however, the failure persisted. The contact stated that the rear passenger’s side power sliding door failed to latch securely. The contact used force while pushing the rear passenger’s side sliding door from the outside to lat…”

Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The remote controller assembly for the passenger-side power sliding door may malfunction, preventing the passenger-side sliding door from securely latching.

Fix: Dealers will replace the passenger-side power sliding door release actuator's drum and holder inside the remote controller assembly, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC221.

Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The plastic fuel rail tube may have been damaged.

Fix: Kia will notify owners, and dealers will inspect, and if necessary, replace the multi-port injection fuel rail, free of charge. The recall began April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC211.

Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Fix: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will inspect and verify whether the vehicle is equipped with a Genuine Kia accessory trailer tow hitch assembly. If equipped, dealers will install a new fuse and wire extension kit. Repairs will be performed free of charge. Owner notification letters were mailed May 16, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC265.

Kia America, Inc. (Kia) is recalling all 2022 and certain 2023 Carnival vehicles. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations.

Fix: Dealers will update the power sliding door control module software, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC266.

Kia America, Inc. (Kia) is recalling certain 2023-2024 Sportage and 2022-2024 Carnival vehicles. The roof molding may loosen and detach.

Fix: Dealers will inspect the roof molding and replace or secure it as necessary, free of charge. Owner notification letters were mailed March 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC292.

Kia America, Inc. (Kia) is recalling certain 2022-2026 Carnival vehicles. Fuel may leak at the pipe connection between the fuel pipe and fuel rail.

Fix: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed June 2, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC368. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on April 24, 2026.