2021 Hyundai Palisade Recalls & Problems

“The contact owns a 2021 Hyundai Palisade. The contact received notification of NHTSA Campaign Number: 25V607000 (Seat Belts); however, the part to complete the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue.”

“The sunroof opened crooked and would not close. After several attempts to close the sunroof a piece of the frame broke.”

“Vehicle Information: 2021 Hyundai Palisade Limited (3.8L V6 Engine) Complaint Description: While driving at highway speeds, the vehicle suddenly began making a loud engine knocking noise, followed immediately by a total and catastrophic structural failure of the engine. A connecting rod bearing seized and the rod broke, punching a hole directly through the metal engine block. This mechanical failu…”

“Blind spot warning system stopped working. Then speedometer stopping working registering 0 both digital and the circle. Then all lights started going off on the dashboard. My dealer cleared codes and errors went to history but not active. When I went to drive again blind spot didn’t work and speedometer didn’t work. I didn’t drive further after that. I heard there was an issue with the 2022 dashbo…”

“While the vehicle was being driven, the sunroof became inoperable, stuck in the tilt position. The motor could be heard running but the glass panel would not move in either direction. There were no warning lamps, messages, or other symptoms before the failure. The dealership disassembled the sunroof and found that a spring on the passenger-side sunroof rail had broken, and that the broken spring …”

“Larsen Automotive in Pine Bluff, AR replaced the spark plugs on this vehicle recently, and while the vehicle was at the shop, I asked the mechanic to look at my suspension as my vehicle has become very rough when driving and I noticed loud "popping/clicking" noises within my vehicle's rear end. The mechanic noted that 2021 Hyundai Palisades had a lot of issues with rear suspension failure and that…”

“I am the original owner of a 2021 Hyundai Palisade SEL AWD (74,225 miles) reporting repeated engine shutdowns in traffic, severe rough idling, and an unresolved safety concern. The problem began XXX. I first brought the vehicle to Hyundai on XXX and have sought service approximately four times since June. Despite technicians stating they could not reproduce the issue, the engine stalled again on …”

“While driving down the freeway my first row sunroof exploded. Insurance wouldn’t cover it because it is a manufacturer defect, but Hyundai wouldn’t cover it because it “isn’t a manufacturer defect.” The temperature outside when the sunroof exploded was 74 degrees and it was cloudy. Then less than 2 months later my engine got a rod knock even with oil changes every 5k miles. No warning signs for ei…”

Hyundai Motor America (Hyundai) is recalling certain 2021 Palisade vehicles. The brake fluid may be contaminated, which can cause the brake master cylinder inner-cup seals to swell, and reduce braking performance.

Fix: Dealers will replace the brake master cylinder, and flush the brake fluid, free of charge. Owner notification letters were mailed on December 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 212.

Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Palisade vehicles. The windshield wiper motor may become inoperative, causing the wipers to fail.

Fix: Dealers will replace the driver-side windshield wiper arm, free of charge. Owner notification letters were mailed December 13, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 233.

Hyundai Motor America (Hyundai) is recalling 2020-2022 Palisade vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and wire extension kit, as necessary, free of charge. Owner notification letters were mailed May 18, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 235.

Hyundai Motor America (Hyundai) is recalling certain 2021-2023 Palisade vehicles. The windshield wiper motor may operate intermittently or fail to operate due to snow or ice buildup on the windshield, causing the wipers to fail.

Fix: Dealers will replace the driver-side windshield wiper arm, free of charge. Owner notification letters were mailed May 15, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 243. This recall is an expansion of recall number 22V-627.

Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.

Fix: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.

Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The side curtain air bags for third-row occupants may deploy improperly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."

Fix: Dealers will install a protective film over the rear window and remove padding, as necessary free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning March 13, 2026. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 292. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 24, 2026.