2023 Toyota Tundra Recalls & Problems

“Recall was issued a year ago on my engine and toyota has yet to do anything about the recall. There is also a second recall for ym tailights , this has been over a year since the recall was issued. First they told me i was to get a new engine in june of 2026. Then in may of 2026 they told me a software test will be completed first to determine if my truck needs a engine. The dealer did state at th…”

“Recall was issued a year ago on my engine and toyota has yet to do anything about the recall. There is also a second recall for ym tailights , this has been over a year since the recall was issued. First they told me i was to get a new engine in june of 2026. Then in may of 2026 they told me a software test will be completed first to determine if my truck needs a engine. The dealer did state at th…”

“Vehicle: 2023 Toyota Tundra TRD Pro Hybrid, VIN [XXX], approximately 40,000 miles. The electronic fuel door release failed due to a corroded fuel door sensor/connector (diagnosed by Premier Toyota, XXX). When the fuel door system does not engage, the tank's refueling valve does not open. As a result, gasoline spits back out of the filler neck during refueling, spilling fuel onto the vehicle and t…”

“The contact owns a 2023 Toyota Tundra. The contact stated that while driving 65 MPH, the vehicle stalled with an audible beeping sound. The engine symbol with an exclamation mark was illuminated for approximately 2 seconds. The message "Engine Stopping - Get to safe side of Road" was immediately displayed on the instrument panel. The contact received notification of NHTSA Campaign Number: 25V76700…”

“turbo's have to be replaced because of a wastegate failure. This is a well known issue. My vehicle is at 66700 miles and Toyota has denied a good will claim. Though they admit there is nothing I could have done differently because its a defective part. My safety is put at risk because the truck goes into limp mode and a "reduced power" message is displayed. The dealership has confirmed the issue b…”

“2023 Toyota Tundra. On July 20, 2026 and again on September 18, 2026, while driving, the truck suddenly lost power and went into limp mode. The dash showed 'Check Engine / Reduced Engine Power / Visit Your Dealer' at about 43,440 miles. The truck had to be towed to the dealer on a flatbed. Losing power without warning in traffic is a serious safety risk. Other ongoing problems: the brakes squeaked…”

“Ive been waiting for years for the previous recalls I have been informed about to get fixed. Feul system,brake lights.Was told by Toyota that someone would call me to come to get them taken care of. In the meantime, constantly checking that my brake lights are working before departing on any excursions in truck & patiently waiting for toyota to reach out when they were gonna fix the first 2 recall…”

“-Our Toyota Tundra Hybrid suffered total catastrophic engine failure due to metal shavings found throughout the engine and oil system. This is the same issue that prompted NHTSA ID Number: 25V767000 recall of Toyota's V35A engines. The tundra is available for inspection. -Statement regarding safety put at risk by my husband: I felt a vibration from the engine compartment (seeming to come from the…”

Gulf States Toyota, Inc. (GST) is recalling certain 2023 Tundra pickup trucks equipped with non-skid spray-on bed liners. The load carrying capacity modification label may indicate less weight than the actual total weight of accessories installed on the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Fix: GST will mail replacement labels to owners, free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 22R2.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles. A software error in the combination meter's electronic control unit (ECU) may cause the Instrument Panel LCD display to go blank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Fix: Dealers will update the combination meter ECU software, free of charge. Owner notification letters are expected to be mailed April 17, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA02.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles that may be equipped with a Toyota genuine accessory tonneau cover. The tonneau cover attachment joints may come loose and allow the cover to detach.

Fix: Owners of the subject vehicles will be notified by first class mail to return their vehicles to a Toyota dealer. Dealer will install new hardware (bolts, spacers, washers, nuts, rubber washers and cotter pins) to the existing bracket and tonneau cover. If the tonneau cover has tears or splits at the mounting holes to the extent that new hardware cannot be installed, it will be replaced with a new tonneau cover and hardware. Owners will receive a notice once the remedy becomes available. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TB03/23TA03.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Tundra, Tundra Hybrid, and Sequoia Hybrid vehicles. The steel chain used to secure the spare tire to the underside of the vehicle may have been insufficiently welded.

Fix: Dealers will replace the spare tire carrier assembly, free of charge. Owner notification letters are expected to be mailed August 14, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TB06/23TA06.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles. The plastic fuel tube routed near metallic brake lines may chafe against the brake lines and become damaged, possibly resulting in a fuel leak.

Fix: Dealers will install protective materials and a clamp on the fuel tube, free of charge. Owner letters were mailed November 6, 2024. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB09/23TA09.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Tundra and Tundra Hybrid vehicles equipped with a spray-on bed liner accessory. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Fix: Dealers will replace the load carrying capacity modification label, free of charge. Owner notification letters are expected to be mailed October 29, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA11.

Southeast Toyota Distributors, LLC (SET) is recalling certain 2022-2024 Toyota Tundra vehicles. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Fix: SET will mail a new modified label, free of charge. Owner notification letters were mailed December 18, 2023. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET23B.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Tundra, Tundra Hybrid, Lexus LX600, and 2023-2024 Sequoia Hybrid vehicles. Unexpected vehicle movement may occur when the vehicle is in neutral and the brakes are not applied.

Fix: Dealers will update the transmission control ECU software, free of charge. Owner notification letters were mailed April 8, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TA02 and 24LA02.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Lexus LX600 vehicles equipped with a V35A engine. Debris from the manufacturing process may contaminate the engine and cause the main bearings to fail, which can result in an engine stall and loss of drive power.

Fix: Dealers will replace the engine assembly, free of charge. Owner letters were mailed between December 17, 2024 and February 19, 2025. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TB07/24TA07 and 24LB04/24LA04.

Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Fix: GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Toyota Tundra and Tundra Hybrid vehicles. Moisture may enter the reverse light assemblies and cause a light failure.

Fix: Dealers will replace both reverse light assemblies and repair the wire harnesses as necessary, free of charge. Owner letters were mailed May 23, 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331.Toyota's numbers for this recall are 24TB06 and 24TA06.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Tundra, Tundra Hybrid, and 2023-2025 Sequoia Hybrid vehicles. A software error may cause the rearview image not to display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Fix: Dealers will update the multimedia display software, free of charge. Owner notification letters were mailed November 19, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB10 and 25TA10.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Toyota Tundra, Lexus LX, and 2024 Lexus GX vehicles equipped with a V35A engine. Debris from the manufacturing process may contaminate the engine and cause the main bearings to fail, which can result in an engine stall and loss of drive power.

Fix: Dealers will perform an inspection on the #1 main bearing using vehicle inspection software and drive data, and if necessary, replace the engine. Repairs will be performed free of charge. Owner letters were mailed August 28, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB14 and 25TA14. Lexus' numbers for this recall are 25LB07 and 25LA07. This recall expands previous NHTSA recall number 24V381.