2022 Kia EV6 Recalls & Problems

“2022 KIA EV6 ICCU failure. Car stopped Level 1 and Level 2 charging. Dealer confirmed failure and replaced under warranty. This was the best of the failure modes, we were not stranded and the 12v battery continued to the charged. Thanks.”

“ICCU failed after 49,059 miles. Levels 1&2 charging do not work. I must use DCFC to charge the car.”

“On [XXX] while traveling to NJ, the vehicle displayed "check electrical system" and would not accept a charge. With only 40 miles of range remaining, I drove the vehicle to Jack Daniels KIA. It is STILL at the dealership, and neither the dealer nor KIA Corp has provided a date that the car will be repaired. The dealer told me that it is covered under the 100kmi powertrain warranty, but that KIA co…”

“1. Severe Safety Concerns (Battery Thermal Risk & Component Interdependency) The PTC (Positive Temperature Coefficient) heater in my vehicle has failed. This component failure has completely disabled my vehicle’s air conditioning (AC) system. In the Kia EV6 architecture, the AC compressor loop is not merely a cabin comfort feature; it is intrinsically linked to the vehicle's thermal management sys…”

“On Sunday, October 4, 2026, the vehicle lost drive power while I was operating it. At the same time, steering became extremely difficult and the brakes required extraordinary physical force to apply. I had to use all of my strength to safely bring the vehicle to a stop. At that point we were stranded in the #2 lane of travel. This was not a minor inconvenience or an isolated warning light; it was …”

“Vehicle Safety Complaint My Kia experienced an ICCU (Integrated Charging Control Unit) failure and was at the dealership for approximately two months while awaiting repairs. The ICCU and related components were replaced, and I was told the vehicle had been repaired. However, immediately after I received the vehicle back, the “Check Electric Vehicle System” warning illuminated again. Since that t…”

“The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 64 MPH, the left side of the steering wheel seized, and the vehicle aggressively jerked to the left into oncoming traffic. The message “Smart Cruise Disabled” was displayed. The contact was able to quickly regain control of the vehicle. The dealer was contacted. The vehicle was not diagnosed or repaired. The manuf…”

“Component that failed: Vehicle headlight/running light has water penetration and the running lights do not stay on. Additionally there is yellowing of the LED running lights, which is a known defect in the Kia EV6. Safety issue: Running lights reduced night time illumination and made it more difficult to see road. Running lights yellowing are a sign of premature failure. Dealer inspection: Dea…”

Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.

Fix: Drivers are recommended to park their vehicles on level ground and avoid parking on a slope/inclined surface whenever possible until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters were mailed May 25, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC236.

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.

Fix: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed April 29, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC302.

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.

Fix: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.

Fix: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 7, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC375. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.