2020 Toyota RAV4 Recalls & Problems

“"Engine Coolant Bypass Valve failed suddenly on highway (Code P2681-15), risking engine overheat and stall. Toyota acknowledged this defect under CSP 24TE04 but refused assistance due to vehicle having 103,660 miles (just past 100k miles). Failure causes immediate safety and overheating hazard."”

“Its the sway bar stabilizer bar in the front end of my 2020 rav4 i bought it brand new in 2020. After just 24k miles i had to replace the sway bar now just a few months later ima gonna have to get it back in the shop because its making the same noise as before”

“Vehicle electrical failure when Driving with the automatic start/stop option turned on Vehicle shows a low voltage abnormality that kills all my electrical components including battery, sometimes it happens while driving on the Highway at 70 speed”

“While driving on the highway, the vehicle suffered a sudden loss of engine power and went into a low-power/vapor lock state due to severe fuel starvation. This created a major safety hazard by stranding the vehicle on the highway shoulder and exposing occupants to high-speed traffic. Prior to the power loss, there were no advance warning lights until the engine stalled. A diagnostic scan performed…”

“Power liftgate hinges separating from body. Lift gate is no longer working as designed, liftgate is inoperable.”

“The contact owns a 2020 Toyota Rav4. The contact stated while driving 40 MPH, the message "Air Bag Fault" was displayed. An independent mechanic was contacted. The vehicle was taken to the independent mechanic to be diagnosed, and it was determined that the air bag needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and filed a case. The approximate fa…”

“During summer 2026 i began to notice a noise/whine above 30mph that would only occur when foot is on accelerator. my vehicle has 83k miles on it (me being only owner with routine maintenance). as a responsible owner, i had my dealer do an inspection. after a drive and a listen, they claimed it was a transmission bearing failure and only solution is a 11k transmission replacement, with the comme…”

“Vehicle electrical failure when Driving with the automatic start/stop option turned on Vehicle shows a low voltage abnormality that kills all my electrical components including battery, sometimes it happens while driving on the Highway at 70 speed”

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Fix: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Fix: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.

Fix: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.

Fix: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.

Fix: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.

Fix: Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.