2020 Kia Telluride Recalls & Problems

“LED running light of driver's side headlamp assembly inoperable On 10/14/24 BOTH headlamp assemblies were under recall warranty and replaced at Sons Kia in McDonough GA. On 10/8/25 I returned to Sons Kia for service and to have the LED checked on the driver's side as it was no longer operable, less than a year after replacement. I was advised there was no warranty on the LED running light but onl…”

“hi- I bought a used Kia Telluride (2020) and after 2 months it stalled out and after 2 different mechanics and a Kia dealership telling me it was fixed- it was not. The car basically had no oil left with zero light or warning. after doing some research, there are tons of people complaining of the same issue. the engine is essentially ruined and needs to be replaced and Kia is not addressing this a…”

“I am filing this safety report regarding my 2020 Kia Telluride, which currently has approximately 133,000 miles. The vehicle is experiencing severe internal oil consumption, burning through multiple quarts of engine oil rapidly between normal service intervals without triggering any dashboard warning lights, creating a high risk of sudden engine failure or stalling at highway speeds. Additionally,…”

“1. What component or system failed or malfunctioned, and is it available for inspection upon request? The panoramic sunroof glass spontaneously failed while the vehicle was being driven on the interstate at approximately 70 mph. A very loud bang, comparable to the sound of a gunshot, was heard from the roof area. After safely pulling over, we observed that the sunroof glass was bowed upward/outwar…”

“The contact owns a 2020 Kia Telluride. The contact stated that while driving approximately 60-65 MPH on the highway, the vehicle suddenly shut off and the battery warning light was flickering and the vehicle lost power. The contact was able to coast the vehicle into a parking lot off the highway where the vehicle remained. The contact replaced the battery; however, approximately one hour later whi…”

“Batter drainage issue. Have paid for a new battery and I just bought the car 09/14/2026”

“This afternoon i noticed that my 2020 Kia Telluride paint has and continues to peel in large chunks in my driveway. All was good this morning and then all of the sudden large pieces of paint started to break away. Near the windshield hood area.”

“I am filing this safety report regarding my 2020 Kia Telluride, which currently has approximately 133,000 miles. The vehicle is experiencing severe internal oil consumption, burning through multiple quarts of engine oil rapidly between normal service intervals without triggering any dashboard warning lights, creating a high risk of sudden engine failure or stalling at highway speeds. Additionally,…”

Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Fix: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.

Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Fix: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.

Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.

Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.

Fix: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.

Fix: Owners are advised to manually engage the emergency parking brake prior to exiting the vehicle until the recall remedy is performed. Dealers will update the electronic parking brake software and replace any damaged intermediate shafts as necessary, free of charge. Owner notification letters were mailed May 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC303.

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob, which can result in a fire while parked or driving.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a bracket for the power seat switch back covers and replace the seat slide knobs, free of charge. Owner notification letters were mailed July 30, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC316.

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob or an improper recall 24V407 repair, which can result in a fire while parked or driving.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install an electronic fuse assembly, free of charge. Owner notification letters are expected to be mailed August 13, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC374. This recall replaces NHTSA recall number 24V407. Vehicles already repaired under the previous recall will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.