2019 Hyundai Santa Fe Recalls & Problems

“On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around …”

“The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously …”

“After Hyundai 9C2 update the transmission bucks or searches for gear causing what seems to be up and down shifting.”

“On August 14 2026, I drove my 2019 Hyundai Santa Fe approximately one mile from my residence to work at approximately 5:00 AM. The vehicle was operating normally and I experienced no warning lights, unusual noises, odors, smoke, or other indications of a problem. I parked the vehicle in an outdoor parking lot and the vehicle remained parked and turned off for approximately four hours. At approxi…”

“The door was completely shut - I was driving on the highway - no alarm on the instrument panel, fully stage 2 latched ( even if it is just stage 1 latched - the instrument panel gives an alarm - there was no alarms about door not fully closed) everything was normal. 15 minutes into the drive - I was exiting the highway, making a right hand turn - the door suddenly popped open, alarm went off on th…”

“Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of the…”

“The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously …”

“internal mechanical failure of the piston rings and cylinder walls. Misfire on Cylinder #2. Further testing revealed that Cylinder #2 is at 80 PSI, which is significantly below the manufacturer's specification. A subsequent leak-down test showed a 90% loss of pressure with air escaping through the oil filler hole. The issue stated above can cause severe mechanical failure of piston rings and c…”

Hyundai Motor America (Hyundai) is recalling certain 2019 Hyundai Santa Fe vehicles. The Side Curtain Air Bag (SCAB) mounting bolts may interfere with and damage the air bags during deployment.

Fix: Hyundai will notify owners, and dealers will install a protective cover over the SCAB installation bolts, free of charge. The recall began December 3, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 177.

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Fix: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.