2018 Toyota 4Runner Recalls & Problems

“Maplewood Toyota dealership service negligence resulted in a severe, 2-tooth mechanical misalignment of the steering intermediate shaft splines. The vehicle was subsequently driven for 11 months under extreme structural binding, inducing unmeasurable metallurgy fatigue on a primary control linkage, internal hydraulic valve balancing failure within the steering gear assembly, and excessive over-ten…”

“I do not know what component or system failed. I was at an appointment with my son when the receptionist informed me that my car alarm was going off and there was smoke coming out of it. I went out to investigate and it sounded like the engine was attempting to start continuously. My key fob would not unlock the car. The engine continued to attempt to start and i was certain the car was going to…”

“Maplewood Toyota dealership service negligence resulted in a severe, 2-tooth mechanical misalignment of the steering intermediate shaft splines. The vehicle was subsequently driven for 11 months under extreme structural binding, inducing unmeasurable metallurgy fatigue on a primary control linkage, internal hydraulic valve balancing failure within the steering gear assembly, and excessive over-ten…”

“On [XXX], my husband was driving our 2018 Toyota 4Runner Limited home from Coventry, CT, with me in the passenger seat. At the second-to-last STOP sign on our route, a yellow slip indicator light suddenly appeared on the dashboard. We did not know why. We wondered if we had accidentally touched a control near the steering wheel. The brakes still worked normally, and my husband stopped completely. …”

“The dealership Direct Motor, located in Manassas, Virginia, sold me this car in poor condition. On Sunday the 22nd, I picked up the car around 10 PM. They didn't show me any information about the car. When I picked it up, I saw that the front bumper and rear door were damaged, and the airbag lights were on, which is dangerous. I returned the car first thing Monday morning and asked them to exchang…”

“The contact owns a 2018 Toyota 4Runner. The contact stated that the frame holding the radiator of the vehicle was severely rusted. The vehicle was taken to the dealer where it was diagnosed that the radiator frame was corroded; however, the dealer applied paint to the structure instead of replacing the part under warranty. The contact later noticed that the radiator frame was corroded. The vehicle…”

“The contact owns a 2018 Toyota 4Runner. The contact stated while driving approximately 25 MPH, the vehicle stalled. The traction control and check engine warning lights were illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The appro…”

“The contact owns a 2018 Toyota 4Runner. The contact stated while driving approximately 25 MPH, the vehicle stalled. The traction control and check engine warning lights were illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The appro…”

Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota 4Runner vehicles that SET modified to be equipped with a TRD wheel package. The Gross Vehicle Weight Rating (GVWR) on the certification label may be incorrect, possibly resulting in the vehicle being overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Fix: SET will notify owners and mail them corrected certification labels, free of charge. The recall began November 28, 2018. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET18A.

Southeast Toyota Distributors, LLC (SET) is recalling certain 2018-2019 Toyota 4Runner vehicles. During installation, certain steering and suspension components may not have been properly tightened.

Fix: SET will notify owners, and dealers will inspect and re-tighten the steering and suspension fasteners as necessary, free of charge. The recall is expected to begin November 19, 2019. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET19B.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Fix: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.

Southeast Toyota Distributors, LLC (SET) is recalling certain 2015-2018 Toyota 4Runner vehicles equipped with an accessory Billet Grille Overlay installed by SET or provided by SET and installed by SET dealers. The U-nut that secures the overlay grille may fracture, allowing the Billet Grille Overlay to detach from the vehicle.

Fix: SET will notify owners, and dealers will replace the securing U-nuts with upgraded hardware, free of charge. The recall is expected to begin January 26, 2018. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET17C.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Fix: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.